• 2022-08-26

When your customers complain to you about insufficient air volume, do you solve the problem? Or open another machine? Every year, a large number of customers ask us for new equipment, and there are many users. Their demand for buying compressors comes from his internal customers (such as production workshops) who put forward this sharp point to him. Problem: Not enough compressed air. 01. The comp...

• 2022-08-26

There are two 457MCL compressors in the public works of a petrochemical company. During operation, oil leakage occurred due to bearing temperature. Bearing operating temperature is the most comprehensive working parameter among various factors reflecting bearing quality. It reflects the influence of the thermal effects associated with internal friction, rolling, vibration, collision and other fact...

• 2022-08-05

Compressed air stations are essential for every plant. During the entire life cycle of being put into use, the cost of purchasing equipment and equipment maintenance only accounts for a small part of the total cost of system operation, while the electricity consumed by the system operation accounts for a small part of the cost. To more than 75% of the total cost of the entire life cycle, so the en...

• 2022-07-01

As summer approaches, air temperatures and humidity rise, and your air compressor will have more water load on the air handling. The air is more humid in summer, and at maximum compressor operating conditions in summer (50°), the water in the air is 650% higher than the maximum temperature (15°) in winter. The temperature rises, the working environment of the air compressor is more severe, and imp...

• 2022-06-20

The principle of centrifugal air compressor: Centrifugal air compressors are speed compressors. The impeller drives the gas to rotate at a high speed, so that the gas generates centrifugal force. Due to the diffused flow of the gas in the impeller, the flow rate and pressure of the gas after passing through the impeller are improved. Continuous production out compressed air. Centrifugal air compre...

• 2022-06-20

1. The machine selection is too small (mainly new machines) How to judge that the air compressor is too small? The general procedure is to close the valve at the back of the air tank and then turn on machine. If the pressure of the pressure gauge above the air storage tank rises rapidly and can reach the rated pressure, open the back end of the valve to use air normally, and the pressure drops rap...

• 2022-02-23

1. Lubrication of the air compressor Air compressors can be divided into the following three categories according to the lubrication method: oil-free compressors, the compressed air does not contact the lubricating oil; oil-lubricated compressors.the moving parts in the compression chamber are lubricated with oil, and the lubricating oil is lubricated by a special oiler or by supply of other parts...

• 2022-02-23

01: Switching sequence 1. Before starting the machine, check whether there is oil leakage in the air compressor pipeline, whether the screws are loose, and confirm the power supply voltage. 2. Before starting the machine, check whether the cooling oil level of the oil drum is between the two marks. If the oil level is lower than the lower mark, add lubricating oil to the oil drum. 3. Before starti...

• 2022-02-23

This article makes a comprehensive analysis and evaluation for the design and safety use of the ultra-high pressure oxygen compression filling system, and proposes measures to prevent explosion accidents. Material combustion has three necessary conditions: combustible material, combustion-supporting material and combustion temperature (ignition source). Oxygen is one of the most common combustion-...

• 2021-12-31

1. Definition of compressed air system The production and use of compressed air is not achieved by a single air compressor, but by a compressed air system. A typical compressed air system consists of the following parts: air compressor, air storage tank, dryer (refrigerated or adsorption type), filter (including oil-water separator, pre-filter, de-oil filter, deodorizing filter, extinguisher) Bact...